Specification(European design)Outside Size:(mm)7110 x 5570 x 3810 mm (L x W x H) Inside Size:(mm)7000 x 4000 x 2800 mm (L x W x H)BasementBasement:Full metal foundation,full grids,the grids are suppressive type of steel grating instead of traditional twisted steel for the cross bar steel grating. The biggest features for it are beautiful,durable and better force bearing. Surface area of foundation:27 M² (full grids)Metal basement:350mm height,the ventilation effect is better than traditional spray booth.Drive-in Ramps:3Units,each size: 2000x1030mm,diamond plate constructionWall and Door Wallboard and Roof Panel:Adopt high quality double construction fireproof insulation EPS panel,thickness: 50mm3-Folded Entrance Door With Safety Glass Window 1 set,size: 3200x2700 mm(B x H),size is bigger than traditional spray booth-Operator's Door With Safety Glass Window Big opening：800x2000mm (B x H)，hand-made,tempering glass observation windowLight SystemCeiling Lighting:8Units,each4×36w,total 1152W ,the grade of lighting box's dustproof and waterproof reach IP54 grade.Side Lighting:8Units,each2×36W,total 576W,grade of lighting box's dustproof and waterproof reach IP54 grade.Brightness:≥1000 LUxFiltration SystemPre-filters:EU3 grade pocket filter system,filtration effect is much betterCeiling Filters:EU5 grade high efficient filterBottom filter & exhaust filter:Fibreglass paint-stop filterVentilation System Inlet fan (Direct Drive Motor):Adopt big impeller turbo fan 7.5KW ，380V，50HZ，CEOutlet fan (Direct Drive Motor):Adopt big impeller turbo fan 7.5KW ，380V，50HZ，CEPainting and baking exchange system:Solenoid valve+ pressure adjustment control cylinder driven damper exchangeFan for water-based paints:On top of cabin installs 2 sets of 1.5kw centrifugal fans,increase system air supply capacity to dry quickerPainting nozzles:Install two rows of nozzles on position of ceiling lighting boxFan Capacity:32.000m³/h Air Flow Speed:0.30 m/s in empty booth,0.30－0.45m/s in loaded boothHeating SystemHeating Exchanger:Adopt high efficient heat-resistant stainless steel as cycling heat exchangerHeating Exchange Capacity:200KW(260.000Kcal/H) Burner Model:Adopt Italy RIELLO diesel burner RG5S,(260.000kal/H),quicker heating and much better effect,more rest assure for quality Heating time:3-5 minutes( from 20°C to 60°C) under baking status,the max baking temperature is 80°CControl board Control system :Standard Y/Δ step-down start control systemPLC controller :Yes,PLC control,more reliable and lower breakdown rate Pressure testing :The pressure gauge indicate the pressure inside cabinFunction:Painting,warm painting,baking,emergency stop switch,alarm indication,failure indication,over-temperature alarm indication,baking delay stop protection
